Your pen facility can make a BIG difference to the workload on your emu ranch. If your pens are built and set up correctly from the start, it will save a lot of headaches for you AND your emus in the future!
Properly constructed emu pens average one acre and comfortably house 40 birds. Shade should be available for the birds and shelter from cold winds. Usually a 24′ x 8′ shed is sufficient because not everyone will be using it at the same time. Half of the north side (12′) needs a wall that is open at the top (about 18″). This is for ventilation in the summer and wind protection in the winter. Emus are hardy animals and do well fine in cold weather., but wind blocker should be available if desired, and some will.
A GREAT Shortcut and Money Saver
Feather fence can be expensive, but there are a few shortcuts. Emu fences must be six feet tall. Emus RARELY get out of a six foot fence. If one is running full speed and hits a fence at an extreme angle, it is possible for the bird to fall, but it is SO rare that major and expensive changes to the fence are not necessary.
Regular 2″ x 4″ x 6′ horsewire is widely used, but it is expensive, and rolls are only 100 feet, so many splices are required. Field cable comes in 330 foot spools. but it costs about the same as 100 feet of horse wire. It’s only 47″ tall, but two rolls can be overlapped (one on top and one on bottom), and the cost is still MUCH less. You can use 8′ T-posts that are two feet apart on the ground and six feet high. Hang the field wire along the bottom, clearing the ground by six inches or so, then overlap the middle by hanging a second coil on top. Secure the two coils with economical and easy to use galvanized rings.
This way you can use two rolls of field wire and get 330 of fence for the same cost as 200 feet of wire and just 200 feet of fence. It’s not really hard to cut the field wire in half (lengthwise) and use half along the top of the fence (above the bottom 47″) and you’ll have half left over for another 330 feet of This way, you get 660 feet of fencing (using three rolls) for the same cost as three rolls of horse wire and 300 feet of fencing…twice the fence for the same cost.
An important shortcut for your doors
Inexpensive, strong and lightweight doors can be made with toro panels at a very reasonable cost. Bull panels are 52″ x 16′ and are made of soldered wire. It’s about the size of a pencil, maybe a little smaller. You’ll need to solder them with a wire welder, but these days they’re so affordable you’d it would pay for itself in no time and they are VERY easy to solder.
Use a chain link top rail frame and weld the stop panel to it. Chain link fence hinges can be welded together and you have a long lasting custom gate. A gate of this nature is strong enough for emus and will hang properly without sagging over time. It is a good idea to install a lag bolt to use as a latch for the door to rest on while in the closed position. You can do this even if you want your door to swing both ways. It’s more trouble, but it’s worth it in the long run.
fence posts
All corner and door posts should be treated wood, not metal. Wood is much better to work with and repairs and changes are much more feasible. Use longer poles or posts (14′ to 16′) for gates and stretch a wire across the top. In this way, clamps are not required on each side of the door. Do this AFTER the fence is built. When you decide where the gate will go, attach the posts or posts, staple them together with wire on both sides, and cut the middle.
When installing posts for emu pens, be sure not to add concrete (bag of concrete) to the ground level. Emus walks on the fence constantly and the concrete will be exposed. Stop about 8 to 10 inches below ground level.
An important shortcut to move Emus from one pen to another
Moving emus from one pen to another is a never-ending task on the emus ranch. It can be extremely stressful for the birds (and for you), depending on the weather, but it’s not necessary. You will need a couple of panels that can be made as your doors. When you need to move birds from one pen to another, temporarily attach a panel to each gate post (with wire) leaving the middle about eighteen inches apart. Make the “funnel” go into the pen you want the birds to go to.
Remove feed and water from the pen the birds are in and place it near the funnel opening in the pen you want the birds to go to. The birds will walk through the funnel and won’t know how to get back. It’s the same basic concept as a fish trap, but for emus. After a day or so, all the birds will have moved and no one will be stressed! If you have one or two stubborn birds, close the funnel opening (so the birds don’t leak in) and leave it. You can use metal rods in the ground at the base of each panel and the top will easily pull apart and snap back together. They’ll get you out of the way and moving in no time. They can smell the water. That is its characteristic desert.
Again, shortcuts make it better for the farmer AND the birds!